| [ Start] | [Questions ] | [ Injector] | [Ignition] | [Trigger] | [Display] | [Wbo] | [Config] | [Table] | [Wiring] | [Idle] |
D.10/7-2008
Newest config, from a running car. Peter Jensen says car starts perfectly if pulled, but does not start if cranked.
- either analog problem
- VR amplitude is too low, or bias voltage too high. Maybe secondary_trigger amplitude or bias problem ?
- or cranking motor interference with VR signal
- they say it's ruled out, scope shows signal OK after LM1815 (but they forgot to measure RPM from scope)
- the min RPM to fire ignition should be around 127 RPM. Normal cranking RPM for this engine is 165-215 RPM. Would be interesting to know what the RPM actually is, when the engine refuses to start.
- the cranking rpm is with is in the range 170-210rpm, and this is also the case when it cant start.
We tested this config with 1.0.78, and after we noticed ign_dualout is used (our tester measures ignch1), and corrected, ign was OK from 80 RPM .. 10k RPM (we raised rev_limit and softrpm_rpm ).
- I will try and upload 1.0.78
- how would you like the voltage measured,under trigger [threre] is cranking voltage from both vr sensors, both are 4v peak-peak
Config
primep_temp_scaling=0D
cwl=46
cwh=1E
cranking_thres=04
awev=32
awev_temp_scaling=1A
awec=C0
warmup_clt_range[0]=00
warmup_clt_range[1]=0C
warmup_clt_range[2]=1E
warmup_clt_range[3]=31
warmup_clt_range[4]=4F
warmup_clt_range[5]=65
warmup_clt_range[6]=79
warmup_clt_range[7]=8C
warmup_clt_range[8]=A9
warmup_clt_range[9]=C8
warmup_clt[0]=B4
warmup_clt[1]=B4
warmup_clt[2]=B4
warmup_clt[3]=A0
warmup_clt[4]=8C
warmup_clt[5]=87
warmup_clt[6]=7D
warmup_clt[7]=6E
warmup_clt[8]=69
warmup_clt[9]=66
warmup_rpm_scale=BF
req_fuel=46
divider=01
alternate=13
injopen=00
battfac=13
kpafac=6E
kpaoffs=37
injocfuel=2A
injrampup_battfac=FF
injpwm=FF
injpwmt=FF
als_launch_input=CC
rpmk[0]=0B
rpmk[1]=B8
tpsdot_kpadot_conf=00
tpsdotrate[0]=02
tpsdotrate[1]=05
tpsdotrate[2]=14
tpsdotrate[3]=28
tpsaq[0]=02
tpsaq[1]=07
tpsaq[2]=0A
tpsaq[3]=14
als_cut_mintps=FF
tpsasync=02
acmult=C8
tpsacold=96
launch_enrich=00
launch_retard=00
overrun_fuelcut=0F
overrun_fuelresume=0F
rev_limit=49
airden_ignore=5A
config11=31
config12=40
config13=06
batt_cal=C6
fastidle=C6
als_max_cut=00
dbaro=0C
tps_low=E9
tps_high=32
fan_temp=F3
fan_hyst=04
fan_channel=40
iac_step_seq=C9
iac_conf=78
iac_max_steps=FF
iac_tps_thres=05
iac_cold_idle_temp=A2
iac_warm_idle_temp=AB
iac_cold_rpm=8C
iac_warm_rpm=55
iac_cold_start_pos=CC
iac_warm_start_pos=CC
iac_afterstart_rpm=1E
iac_afterstart_duration=50
iac_speed=00
iac_kp=6E
iac_ki=0F
iac_kd=05
launch_rpm=14
iac_integral_limit_dec=32
iac_integral_limit_inc=A0
iac_integral_deadband=05
iac_deadband=0A
als_cut_maxtps=00
iac_overclose_interval=02
iac_ref_pos[0]=CC
iac_ref_pos[1]=CC
iac_ref_pos[2]=CC
iac_ref_pos[3]=C2
iac_ref_pos[4]=BF
iac_ref_pos[5]=BF
iac_ref_pos[6]=BF
iac_ref_pos[7]=BF
iac_ref_pos[8]=BF
iac_ref_pos[9]=BF
iac_sol_channel=60
iac_ign_slope=14
softrpm_range=32
iac_ign_advance_limit=14
iac_ign_retard_limit=14
iac_ign_threshold=04
ego_conf=06
ego_lag=02
ego_coolant=B4
ego_maxtps=E6
ego_maxmap=96
ego_minrpm=07
ego_maxrpm=50
ego_warmup=3C
ego_lean_limit=33
ego_rich_limit=1A
ego_pid_kp=28
als_enrich=00
ego_delta=08
ego_target=19
ego_pid_window=FF
wbo2_warmup_ramp=A0
als_react_tps=00
wbo2_abs_limit=E4
wbo2_limit_maxt=A0
wbo2_fallback=B0
wbo2_retry_t=06
wbo2_edgetime_corr=BA
wbo2_edgetime_min=50
wbo2_ri_target=96
wbo2_nernstdc_target=89
wbo2_pump_pw_zero=65
wbo2_calibration=BE
wbo2_heater_pid_kp=46
wbo2_heater_pid_ki=10
wbo2_heater_pid_kd=1A
wbo2_heater_pid_ilimit=80
wbo2_pump_pid_kp=15
wbo2_pump_pid_ki=4E
wbo2_pump_pid_kd=00
wbo2_pump_pid_ilimit=84
wbo2_ri_confidence_scale=80
knock_conf=01
knock_sampling_window=F3
knock1_frequency=26
knock1_gain=00
knock1_integrator=0F
knock2_frequency=29
knock2_gain=3F
knock2_integrator=1F
knock_threshold=FF
knock_noise_scale=FF
knock_max_retard=00
knock_default_retard=00
knock_retard_step=00
knock_retard_delay=00
knock_advance_step=00
knock_advance_delay=00
knock_minrpm=FF
knock_maxrpm=FF
ve_learn_coolant=D8
ve_learn_max_power=FF
ve_learn_rpm_scale=1E
ve_learn_kpa_scale=1E
ve_learn_ego_scale=43
ve_learn_min_weight=4D
ve_learn_speed=FF
ve_learn_limit=33
ve_learn_conf=00
lcd_c0=FE
lcd_delay=FF
lcd_backlight=FF
kpa_conf=21
ign_balance=00
als_retard_mintps=FF
als_retard_maxtps=00
lcd_default_view=00
primary_trigger=29
secondary_trigger=59
tooth_wheel=02
trigger_tooth=00
another_trigger_tooth=03
crank_minper=BC
tooth_wheel_twidth1=00
tooth_wheel_twidth2=00
cam_sync_r_edge_phase=00
cam_sync_f_edge_phase=00
reset_engphase_after=04
ign_tdcdelay=88
ign_dwell14=2F
ign_dwell6=38
ign_crank_advance=20
ign_out=72
ignchmax=01
engine_off_delay=04
pump_on_mintime=04
fuelpump_channel=50
inj_stage2_rate=FF
inj_stage2_start_tps=FF
inj_stage2_start_map=FF
als_deact_rpm=FF
als_deact_time=01
als_deact_egt=00
als_retard=00
als_rev_limit=40
misc1out_minrpm=00
misc1out_maxrpm=46
misc1out_mintps=00
misc1out_maxtps=B3
misc1out_minmap=00
misc1out_maxmap=82
misc1out_channel=07
misc2out_minrpm=FF
misc2out_maxrpm=FF
misc2out_mintps=FF
misc2out_maxtps=FF
misc2out_minmap=FF
misc2out_maxmap=FF
misc2out_channel=FF
act_wot_rpm=FF
act_wot_channel=FF
act_rpm_rpm=FF
act_rpm_channel=FF
egt1_cal=47
als_tks_channel=FF
boost_conf=ED
boost_targetoffs=00
boost_minpressure=41
boost_pid_kp=20
boost_pid_ki=80
boost_pid_kd=01
boost_pid_ilimit=FF
boost_channel=4F
water_pump_temp=00
hybrid_rpm_a=00
hybrid_rpm_m=00
water_pump_hyst=00
water_pump_channel=76
toothrel_normal=01
toothrel_missing=F0
fuelcut_min_kpa=14
fuelcut_max_kpa=E6
tach_channel=17
tach_div=10
shiftcut_conf=01
shiftcut_channel=FF
shiftcut_time=00
softrpm_rpm=4B