MembersPage/TormasiAudiAan

The car uses a conservative street program perfect, als, launch turning up.

üdv: Ákos

A motronic55 install might save some time making a harness, but you must always verify the harness reasonably carefully.

This involves


Documents and files to use


Sensor measurements

Measure sensor resistance against AANpin30.

Take note of the temperature. If the engine is stopped for hours, the coolant and MAT will be close to ambient temperature.

Injector and idle-air output measurements

Measure injector and idle air pins against AANpin37 (that is the flyback pin, same function as EC36pin23 in standard VEMS docs)


Grounds

Measure that grounds are strongly (max 0.1 Ohm) connected inside the VEMS ECU.

You can measure that most are connected in the harness, but at least AANpin30 (sensor ground) and AANpin48 trigger ground are likely not connected.

Measure that all the above grounds are connected inside the ECU.


Trigger

This step assumes you successfully made all the above steps.

This needs ignition on.

The secondary trigger crankhome-VR is already reversed. Resistance=...


Trigger

Measure trigger resistance against AANpin48.

HALL signal

This step assumes you successfully made all the above steps.


WBO2 on SSC4 male standard (not used any longer), SSC5 is default now

WBO2 Rcal

Resistance between pin2 and pin6 of the 6pin WBO2 connector: 103 Ohm

http://www.vems.hu/files/MembersPage/TormasiAudiAAN/ has some msq files.

The ignition output channels are suspicios. channel 4 assigned to 2 cylinders.

Az autó tökéletesen működik, ALS, LAUNCH CONTROL beállítva, és egy konzervatív utcai programra hangolva. üdv: Kovács Ákos

--

Try 1.1.23 instead of 1.1.24 but obviously the recommended config was not uploaded (or changed for the bad):

Terminal log file

Date: 2007.08.16. - 11:07:42


primep=00

primep_temp_scaling=33

cwl=A0

cwh=32

cranking_thres=03

awev=63

awev_temp_scaling=4A

awec=11

warmup_clt_range[0]=00

warmup_clt_range[1]=00

warmup_clt_range[2]=14

warmup_clt_range[3]=28

warmup_clt_range[4]=50

warmup_clt_range[5]=64

warmup_clt_range[6]=78

warmup_clt_range[7]=8C

warmup_clt_range[8]=AA

warmup_clt_range[9]=C8

warmup_clt[0]=C8

warmup_clt[1]=C8

warmup_clt[2]=AA

warmup_clt[3]=8C

warmup_clt[4]=82

warmup_clt[5]=7B

warmup_clt[6]=78

warmup_clt[7]=73

warmup_clt[8]=6E

warmup_clt[9]=64

warmup_rpm_scale=A8

req_fuel=4B

divider=01

alternate=04

injopen=00

battfac=22

kpafac=97

kpaoffs=94

injocfuel=08

injrampup_battfac=FF

injpwm=FF

injpwmt=FF

als_launch_input=67

rpmk[0]=09

rpmk[1]=60

tpsdot_kpadot_conf=00

tpsdotrate[0]=06

tpsdotrate[1]=0A

tpsdotrate[2]=11

tpsdotrate[3]=1E

tpsaq[0]=07

tpsaq[1]=09

tpsaq[2]=0E

tpsaq[3]=14

als_cut_mintps=52

tpsasync=03

acmult=6E

tpsacold=14

launch_enrich=0D

launch_retard=A0

overrun_fuelcut=10

overrun_fuelresume=0F

rev_limit=4A

airden_ignore=61

config11=41

config12=40

config13=02

batt_cal=C6

fastidle=C6

als_max_cut=0A

dbaro=0A

tps_low=16

tps_high=E6

fan_temp=EA

fan_hyst=05

fan_channel=FF

iac_step_seq=D8

iac_conf=18

iac_max_steps=C8

iac_tps_thres=05

iac_cold_idle_temp=63

iac_warm_idle_temp=B4

iac_cold_rpm=6E

iac_warm_rpm=55

iac_cold_start_pos=B3

iac_warm_start_pos=6B

iac_afterstart_rpm=0A

iac_afterstart_duration=19

iac_speed=05

iac_kp=32

iac_ki=19

iac_kd=0A

launch_rpm=27

iac_integral_limit_dec=23

iac_integral_limit_inc=78

iac_integral_deadband=14

iac_deadband=32

als_cut_maxtps=59

iac_overclose_interval=C8

iac_ref_pos[0]=BF

iac_ref_pos[1]=BA

iac_ref_pos[2]=AD

iac_ref_pos[3]=A8

iac_ref_pos[4]=A1

iac_ref_pos[5]=91

iac_ref_pos[6]=82

iac_ref_pos[7]=7A

iac_ref_pos[8]=75

iac_ref_pos[9]=73

iac_sol_channel=60

iac_ign_slope=14

softrpm_range=19

iac_ign_advance_limit=20

iac_ign_retard_limit=18

iac_ign_threshold=18

ego_conf=06

ego_lag=04

ego_coolant=7E

ego_maxtps=E6

ego_maxmap=69

ego_minrpm=07

ego_maxrpm=46

ego_warmup=14

ego_lean_limit=26

ego_rich_limit=26

ego_pid_kp=1E

als_enrich=00

ego_delta=03

ego_target=19

ego_pid_window=01

wbo2_warmup_ramp=FF

als_react_tps=66

wbo2_abs_limit=E0

wbo2_limit_maxt=F0

wbo2_fallback=70

wbo2_retry_t=06

als_retard_rpm1=00

als_retard_rpm2=00

wbo2_ri_target=A5

wbo2_nernstdc_target=86

wbo2_pump_pw_zero=66

wbo2_calibration=A9

wbo2_heater_pid_kp=45

wbo2_heater_pid_ki=11

wbo2_heater_pid_kd=1A

wbo2_heater_pid_ilimit=80

wbo2_pump_pid_kp=15

wbo2_pump_pid_ki=4E

wbo2_pump_pid_kd=00

wbo2_pump_pid_ilimit=FF

wbo2_ri_confidence_scale=80

knock_conf=01

knock_sampling_window=F2

knock1_frequency=29

knock1_gain=0E

knock1_integrator=14

knock2_frequency=29

knock2_gain=00

knock2_integrator=00

knock_threshold=0A

knock_noise_scale=D8

knock_max_retard=18

knock_default_retard=04

knock_retard_step=04

knock_retard_delay=30

knock_advance_step=01

knock_advance_delay=50

knock_minrpm=0A

knock_maxrpm=42

ve_learn_coolant=CF

ve_learn_max_power=64

ve_learn_rpm_scale=28

ve_learn_kpa_scale=28

ve_learn_ego_scale=50

ve_learn_min_weight=14

ve_learn_speed=32

ve_learn_limit=80

ve_learn_conf=01

lcd_c0=FE

lcd_delay=42

lcd_backlight=FF

kpa_conf=22

als_igncut_rpm2=00

als_retard_mintps=66

als_retard_maxtps=99

lcd_default_view=00

primary_trigger=43

secondary_trigger=19

tooth_wheel=5A

trigger_tooth=08

another_trigger_tooth=12

crank_minper=00

tooth_wheel_twidth1=20

tooth_wheel_twidth2=00

cam_sync_r_edge_phase=00

cam_sync_f_edge_phase=00

reset_engphase_after=40

ign_tdcdelay=84

ign_dwell14=30

ign_dwell6=4A

ign_crank_advance=28

ign_out=70

ignchmax=04

engine_off_delay=02

pump_on_mintime=04

fuelpump_channel=50

inj_stage2_rate=FF

inj_stage2_start_tps=FF

inj_stage2_start_map=FF

als_igncut_rpm1=00

als_deact_time=04

als_deact_egt=77

als_retard=5A

als_rev_limit=64

misc1out_minrpm=FF

misc1out_maxrpm=FF

misc1out_mintps=FF

misc1out_maxtps=FF

misc1out_minmap=FF

misc1out_maxmap=FF

misc1out_channel=FF

misc2out_minrpm=FF

misc2out_maxrpm=FF

misc2out_mintps=FF

misc2out_maxtps=FF

misc2out_minmap=FF

misc2out_maxmap=FF

misc2out_channel=FF

act_wot_rpm=FF

act_wot_channel=FF

act_rpm_rpm=FF

act_rpm_channel=FF

egt1_cal=4A

als_tks_channel=F7

boost_conf=66

boost_targetoffs=00

boost_minpressure=3A

boost_pid_kp=D6

boost_pid_ki=46

boost_pid_kd=2C

boost_pid_ilimit=7D

boost_channel=62

water_pump_temp=00

hybrid_rpm_a=00

hybrid_rpm_m=00

water_pump_hyst=7E

water_pump_channel=FF

toothrel_normal=76

toothrel_missing=00

fuelcut_min_kpa=08

fuelcut_max_kpa=90

tach_channel=07

tach_div=10

shiftcut_conf=00

shiftcut_channel=FF

shiftcut_time=7F

softrpm_rpm=50

j[0]=4780 4B80 597F 5E7F 657F 657F 647F 637F 637F 637F 637F 637F

j[1]=4C80 5380 5A80 617F 6480 677F 647F 637F 637F 637F 637F 637F

j[2]=52F8 5D80 5F80 657F 6580 6580 647F 637F 637F 637F 637F 637F

j[3]=5980 627F 647F 6480 6780 687F 667F 667F 657F 647F 647F 637F

j[4]=617F 647F 687F 697F 6B7F 697F 6A7F 677F 667F 677F 647F 657F

j[5]=647F 677F 697F 6D7F 6D7F 6D7F 6E7F 6E7F 6D7F 6E7F 6E7F 6C7F

j[6]=657F 687F 6A7F 6C7F 6D7F 707F 7580 767F 7A7F 7B7F 7B7F 7A7F

j[7]=6C7F 6A7F 6C7F 6E7F 717F 7480 7780 7980 7C80 7D80 8080 8080

j[8]=707F 707F 6F7F 717F 737F 7480 7880 7A80 7B80 7E80 7F80 8280

j[9]=787F 787F 767F 747F 757F 7480 7680 7680 7880 7A80 7B80 7F80

j[A]=7B7F 7B7F 797F 787F 7A80 7A80 7880 7480 7480 7780 7980 7D80

j[B]=827F 827F 847F 8380 7F80 7D80 7B80 7680 7580 7680 7680 7880

l[0]=37 37 2F 2C 2F 34 37 37 37 37 37 37

l[1]=37 37 2F 2C 2C 2F 34 37 37 37 37 37

l[2]=37 37 2F 2C 2C 2C 31 37 37 37 37 37

l[3]=37 37 2F 2C 2C 2C 31 36 37 37 37 3B

l[4]=37 39 37 3B 39 37 39 3B 3F 40 43 43

l[5]=3F 3F 43 43 3F 3F 43 44 47 4D 4B 4D

l[6]=4D 4D 4D 4D 47 47 44 47 4D 51 51 55

l[7]=53 55 58 58 55 51 55 58 5A 5A 5C 5C

l[8]=58 5A 58 58 5A 5E 61 66 66 63 63 61

l[9]=68 66 6B 6B 6D 6D 6D 6D 6D 70 70 6D

l[A]=75 75 75 75 75 75 75 7B 78 7B 75 75

l[B]=78 78 78 7E 81 81 83 83 83 83 7E 7E

n[0]=3C 37 5E 8E 9B 9B 9B 9B 9B 9B 9B 98

n[1]=37 37 5E 8C 9B 9B 9B 9B 9B 9B 9B 98

n[2]=37 37 5E 8B 9B 9B 9B 9B 9B 9B 9B 98

n[3]=37 37 59 8B 9B 9B 9B 9B 9B 9B 9B 98

n[4]=35 35 58 87 99 9B 9B 9B 9B 9B 9B 98

n[5]=33 33 53 83 96 9A 9B 9B 9A 99 98 94

n[6]=2E 30 50 7C 8F 93 95 95 94 93 92 8F

n[7]=2E 2E 48 73 83 8A 8A 8D 8B 8A 8A 89

n[8]=2E 2E 40 69 77 7E 80 81 81 80 81 7F

n[9]=2E 2E 35 5C 6C 72 74 76 77 77 76 75

n[A]=2E 2E 30 4F 5F 65 65 66 68 68 68 67

n[B]=2E 2E 30 3C 4C 51 53 55 57 58 59 55

k[0]=0B 12 19 21 28 32 3F 4B 58 64 71 87

r[0]=07 0C 11 16 1C 21 27 2C 31 37 3C 45

h[0]=01 02 04 08 10 20 40 80

h[1]=00 48 36 24 12 00 00 00

h[2]=36 46 56 66 40 50 50 50

b[0]=3B 3B 37 34 34 31 31 34 37 37 3B 3D

1.1.23