Cranking RPM signal is OK (stable 190-210 RPM), but engine does not start.
- ECU, and the crankshaft sensor was exchanged hall, with a 12-1 homemade wheel.
- I exchanged the original cable for shielded cable. Primary trigger signal ec 36/27
- I exchanged the ignition, and the cables of the coil.
- using 2 audi coils
- all sensor measures, and works
Since the engine hasn't yet started after assembly, Maybe a mechanical (valve-control?) problem?
I use wasted spark ( the engine worked with these earlier ).
ignition order 1-3-2-4 (known from ?)
ignition outputs
- cylinder 1-2 ec36/33 ignch1
- cylinder 3-4 ec36/35 ignch0
fuel it:
- cylinder1 ec36/7 mask1
- cylinder2 ec36/19 mask2
- cylinder3 ec36/8 mask4
- cylinder4 ec36/20 mask8
The engine does not start up. Feeling like that as if would spark in bad time. wasted spark ignition.
OLD (when VR sensor was used:) is way too little information but it sounds like an improperly made home-made 12-1 wheel (do you have a photo?) with too big amplitude at the trigger tooth. At the primary trugger LM1815, change to R181=270k (instead of 150k) to allow lower "relative tooth amplitude"
I checked the engine mechanicswise, and I hit home properly. Multimeter an injection is measured in all cylinders, and spark the plug.
FULL wiring please
Trigger 12-1 VR ?
- TODO: description
- polarity measurements (not needed for HALL)
- TODO: DC voltage bias measurement
And take logs. Watch wheel error.
appropriate:
- primary_trigger=11
- primary_trigger=10 means falling edge. Not showstopper, but for VR configure rising edge
- secondary_trigger=02
- tooth_wheel=0B
- trigger_tooth=00
- another_trigger_tooth=06
- tooth_wheel_twidth1=78
- tooth_wheel_twidth2=00
- reset_engphase_after=A0
- h[1]=00 06 00 06 FF FF FF FF
- h[2]=00 10 00 10 00 00 00 00
Terminal log file
Date: 2008.09.20. - 16:42:36
primep=00
primep_temp_scaling=00
cwl=46
cwh=1E
cranking_thres=03
awev=14
awev_temp_scaling=26
awec=02
warmup_clt_range[0]=00
warmup_clt_range[1]=00
warmup_clt_range[2]=00
warmup_clt_range[3]=0C
warmup_clt_range[4]=50
warmup_clt_range[5]=64
warmup_clt_range[6]=78
warmup_clt_range[7]=8C
warmup_clt_range[8]=AA
warmup_clt_range[9]=C8
warmup_clt[0]=BE
warmup_clt[1]=B4
warmup_clt[2]=AA
warmup_clt[3]=A0
warmup_clt[4]=96
warmup_clt[5]=8C
warmup_clt[6]=78
warmup_clt[7]=73
warmup_clt[8]=6E
warmup_clt[9]=69
warmup_rpm_scale=80
req_fuel=5A
divider=01
alternate=13
injopen=00
battfac=1C
kpafac=C3
kpaoffs=9C
injocfuel=2A
injrampup_battfac=FF
injpwm=FF
injpwmt=FF
als_launch_input=67
rpmk[0]=0B
rpmk[1]=B8
tpsdot_kpadot_conf=00
tpsdotrate[0]=05
tpsdotrate[1]=14
tpsdotrate[2]=28
tpsdotrate[3]=4D
tpsaq[0]=05
tpsaq[1]=07
tpsaq[2]=0C
tpsaq[3]=0E
als_cut_mintps=8C
tpsasync=04
acmult=A0
tpsacold=14
launch_enrich=0D
launch_retard=78
overrun_fuelcut=0C
overrun_fuelresume=0B
rev_limit=46
airden_ignore=62
config11=30
config12=30
config13=0A
batt_cal=C5
fastidle=80
als_max_cut=0D
dbaro=44
tps_low=14
tps_high=96
fan_temp=EA
fan_hyst=02
fan_channel=4F
iac_step_seq=C9
iac_conf=40
iac_max_steps=C8
iac_tps_thres=99
iac_cold_idle_temp=90
iac_warm_idle_temp=A2
iac_cold_rpm=82
iac_warm_rpm=55
iac_cold_start_pos=B3
iac_warm_start_pos=73
iac_afterstart_rpm=0A
iac_afterstart_duration=0A
iac_speed=06
iac_kp=30
iac_ki=0F
iac_kd=23
launch_rpm=2B
iac_integral_limit_dec=5A
iac_integral_limit_inc=F0
iac_integral_deadband=0A
iac_deadband=05
als_cut_maxtps=A6
iac_overclose_interval=B8
iac_ref_pos[0]=85
iac_ref_pos[1]=82
iac_ref_pos[2]=80
iac_ref_pos[3]=7D
iac_ref_pos[4]=7A
iac_ref_pos[5]=7A
iac_ref_pos[6]=78
iac_ref_pos[7]=75
iac_ref_pos[8]=73
iac_ref_pos[9]=70
iac_sol_channel=5F
iac_ign_slope=28
softrpm_range=32
iac_ign_advance_limit=10
iac_ign_retard_limit=24
iac_ign_threshold=08
ego_conf=06
ego_lag=0A
ego_coolant=87
ego_maxtps=FF
ego_maxmap=96
ego_minrpm=05
ego_maxrpm=64
ego_warmup=1E
ego_lean_limit=00
ego_rich_limit=00
ego_pid_kp=40
als_enrich=0D
ego_delta=1A
ego_target=19
ego_pid_window=FF
wbo2_warmup_ramp=A0
als_react_tps=B3
wbo2_abs_limit=E4
wbo2_limit_maxt=A0
wbo2_fallback=60
wbo2_retry_t=06
wbo2_edgetime_corr=0E
wbo2_edgetime_min=15
wbo2_ri_target=96
wbo2_nernstdc_target=8D
wbo2_pump_pw_zero=64
wbo2_calibration=BE
wbo2_heater_pid_kp=46
wbo2_heater_pid_ki=10
wbo2_heater_pid_kd=1A
wbo2_heater_pid_ilimit=80
wbo2_pump_pid_kp=40
wbo2_pump_pid_ki=2E
wbo2_pump_pid_kd=08
wbo2_pump_pid_ilimit=84
wbo2_ri_confidence_scale=80
knock_conf=00
knock_sampling_window=F2
knock1_frequency=29
knock1_gain=00
knock1_integrator=14
knock2_frequency=22
knock2_gain=05
knock2_integrator=00
knock_threshold=FF
knock_noise_scale=D8
knock_max_retard=00
knock_default_retard=00
knock_retard_step=00
knock_retard_delay=FF
knock_advance_step=00
knock_advance_delay=3A
knock_minrpm=46
knock_maxrpm=FF
ve_learn_coolant=D8
ve_learn_max_power=FF
ve_learn_rpm_scale=1E
ve_learn_kpa_scale=1E
ve_learn_ego_scale=43
ve_learn_min_weight=4D
ve_learn_speed=FF
ve_learn_limit=FF
ve_learn_conf=00
lcd_c0=FE
lcd_delay=FF
lcd_backlight=FF
kpa_conf=22
ign_balance=48
als_retard_mintps=80
als_retard_maxtps=99
lcd_default_view=00
primary_trigger=10
secondary_trigger=02
tooth_wheel=0B
trigger_tooth=00
another_trigger_tooth=06
crank_minper=50
tooth_wheel_twidth1=78
tooth_wheel_twidth2=00
cam_sync_r_edge_phase=FF
cam_sync_f_edge_phase=FF
reset_engphase_after=A0
ign_tdcdelay=64
ign_dwell14=2F
ign_dwell6=25
ign_crank_advance=14
ign_out=70
ignchmax=03
engine_off_delay=04
pump_on_mintime=04
fuelpump_channel=60
inj_stage2_rate=FF
inj_stage2_start_tps=00
inj_stage2_start_map=FF
als_deact_rpm=46
als_deact_time=50
als_deact_egt=78
als_retard=46
als_rev_limit=50
misc1out_minrpm=78
misc1out_maxrpm=78
misc1out_mintps=00
misc1out_maxtps=00
misc1out_minmap=00
misc1out_maxmap=00
misc1out_channel=5F
misc2out_minrpm=66
misc2out_maxrpm=66
misc2out_mintps=00
misc2out_maxtps=00
misc2out_minmap=00
misc2out_maxmap=00
misc2out_channel=0F
act_wot_rpm=4F
act_wot_channel=FF
act_rpm_rpm=3C
act_rpm_channel=50
egt1_cal=48
als_tks_channel=68
boost_conf=00
boost_targetoffs=00
boost_minpressure=35
boost_pid_kp=00
boost_pid_ki=00
boost_pid_kd=00
boost_pid_ilimit=00
boost_channel=4F
water_pump_temp=00
hybrid_rpm_a=00
hybrid_rpm_m=00
water_pump_hyst=00
water_pump_channel=3F
toothrel_normal=84
toothrel_missing=16
fuelcut_min_kpa=0A
fuelcut_max_kpa=8C
tach_channel=07
tach_div=11
shiftcut_conf=00
shiftcut_channel=FF
shiftcut_time=01
softrpm_rpm=45
j[0]=2680 2680 2880 2980 2880 2880 2780 2980 2B80 2B80 2B80 3380
j[1]=2B80 2E80 2D80 2F80 3380 3380 3480 3580 3580 3980 3A80 4280
j[2]=3080 3380 3480 3380 3580 3480 3580 3780 3B80 3D80 4280 4A80
j[3]=2F80 3180 3480 3680 3780 3980 3780 3A80 3D80 4180 4480 4D80
j[4]=3380 3380 3880 3A80 3D80 3C80 3B80 3D80 4180 4380 4680 5180
j[5]=3480 3580 3580 3A80 3D80 3B80 3B80 3E80 4280 4980 4D80 5580
j[6]=3B80 3E80 3B80 3C80 3F80 3D80 3F80 4180 4380 4A80 4F80 5680
j[7]=3F80 4080 4280 4280 4580 4380 4780 4A80 4F80 5580 5F80 6580
j[8]=5D80 5E80 5A80 5880 5580 5880 5B80 6580 6C80 7180 7480 7380
j[9]=5F80 6080 5B80 5B80 5C80 5D80 6280 6980 6E80 7180 7480 7280
j[A]=5A80 5B80 5C80 5C80 5E80 6080 6180 6880 6C80 6F80 7180 6F80
j[B]=5580 5780 5780 5A80 5A80 5C80 5F80 6280 6680 6980 6B80 6980
l[0]=47 47 47 47 47 47 47 47 47 47 47 47
l[1]=47 47 47 47 47 47 47 47 47 47 47 47
l[2]=48 48 48 48 48 48 48 48 48 4D 4D 4D
l[3]=4D 4D 4D 4D 4D 4D 4D 4D 4D 4F 4F 4F
l[4]=55 55 55 55 55 55 55 55 55 55 55 5C
l[5]=5C 5C 5C 5C 5C 5C 5C 63 63 63 63 63
l[6]=66 66 66 66 66 66 66 66 66 6B 6B 6B
l[7]=6B 6B 6B 6B 6B 6B 6B 6B 70 70 70 75
l[8]=70 70 70 70 70 70 70 70 70 70 75 75
l[9]=75 75 75 75 75 75 75 75 75 75 75 75
l[A]=75 75 75 7E 7E 7E 7E 7E 7E 7E 7E 7E
l[B]=7E 7E 7E 7E 7E 7E 7E 81 81 81 81 81
n[0]=28 5A 71 81 8B 8F 93 97 99 9C 9E 9D
n[1]=28 5A 6E 7F 8A 8E 92 96 99 9C 9E 9D
n[2]=28 5A 6B 7D 8A 8E 93 97 99 9C 9C 9C
n[3]=27 59 6B 7C 86 8C 90 94 97 98 9A 94
n[4]=28 58 6A 78 81 88 8B 8E 90 92 92 8B
n[5]=28 54 67 72 7B 7E 82 84 84 84 84 7E
n[6]=28 4F 60 68 6E 71 73 73 73 72 72 6F
n[7]=28 45 55 5B 61 62 62 61 62 62 60 5E
n[8]=28 39 45 4A 4C 4E 4E 4F 4E 4D 4D 48
n[9]=28 31 38 3C 3C 3D 3D 3E 3D 3C 3B 37
n[A]=22 29 2A 2B 2B 2B 2C 2C 2C 2D 2C 28
n[B]=1C 1C 1C 1C 1C 1C 1C 1C 1C 1C 1C 1D
k[0]=0B 14 1E 2D 37 41 50 5F 73 82 91 A0
r[0]=07 0C 11 16 1C 21 27 2C 31 37 3C 49
h[0]=02 08 04 01 00 00 40 00
h[1]=00 06 00 06 FF FF FF FF
h[2]=00 10 00 10 00 00 00 00
b[0]=32 4B 64 7D 7D 7D 7D 7D 7D 7D 78 78
t[0]=FF FF FF FF FF FF FF FF
1.0.73
Bye
Date: 2008.09.20. - 16:43:14
End log file
Date: 2008.09.02. - 17:40:16