I would like to ask for help! The engine of the car does not work in the future. ECU, and the crankshaft sensor was exchanged hall. I exchanged the original one for shaded cable. I exchanged it the ignition, and the cables of the coil. I prepared it a fresh dump, and may be if nobody finds a mistake in him that there is a mechanics problem?
The lounge which can be got in the Webshop sensor I use it. 2 pieces of audi coil I am useful ( the engine used these early ) wasted spark apply.
ignition order 1-3-2-4
1-2 cylinders ec36/33 outputs I use it.
3-4 cylinders ec36/35 outputs I use it.
fuel it:
Into 1 cylinder ec36/7 outputs control it
Into 2 cylinders ec36/19
Into 3 cylinders ec36/8
Into 4 cylinders ec36/20
primer trigger signal ec 36/27 ( engine turn at the time of a launch stable 190-210rpm )
all sensor measures, and works
The engine does not start up. Feeling like that as if would spark in bad time. wasted spark ignition.
There is way too little information but it sounds like an improperly made home-made 12-1 wheel (do you have a photo?) with too big amplitude at the trigger tooth. At the primary trugger LM1815, change to R181=270k (instead of 150k) to allow lower "relative tooth amplitude"
ignition outputs
- ec36-33
- ec36-35
Inj - for which cyl ? This is a boxer, not 1342 but ..... fill this in!
- ec36/7
- ec36/8
- ec36/19
- ec36/20
I checked the engine mechanicswise, and I hit home properly. Multimeter an injection is measured in all cylinders, and spark the plug.
FULL wiring please
Trigger 12-1 VR ?
- TODO: description
- TODO: polarity measurements
- TODO: DC voltage bias measurement
And take logs. Watch wheel error.
appropriate:
- primary_trigger=11
- primary_trigger=10 means falling edge. Not showstopper, but for VR configure rising edge
- secondary_trigger=02
- tooth_wheel=0B
- trigger_tooth=00
- another_trigger_tooth=06
- tooth_wheel_twidth1=78
- tooth_wheel_twidth2=00
- reset_engphase_after=A0
- h[1]=00 06 00 06 FF FF FF FF
- h[2]=00 10 00 10 00 00 00 00
Terminal log file
Date: 2008.09.20. - 16:42:36
primep=00
primep_temp_scaling=00
cwl=46
cwh=1E
cranking_thres=03
awev=14
awev_temp_scaling=26
awec=02
warmup_clt_range[0]=00
warmup_clt_range[1]=00
warmup_clt_range[2]=00
warmup_clt_range[3]=0C
warmup_clt_range[4]=50
warmup_clt_range[5]=64
warmup_clt_range[6]=78
warmup_clt_range[7]=8C
warmup_clt_range[8]=AA
warmup_clt_range[9]=C8
warmup_clt[0]=BE
warmup_clt[1]=B4
warmup_clt[2]=AA
warmup_clt[3]=A0
warmup_clt[4]=96
warmup_clt[5]=8C
warmup_clt[6]=78
warmup_clt[7]=73
warmup_clt[8]=6E
warmup_clt[9]=69
warmup_rpm_scale=80
req_fuel=5A
divider=01
alternate=13
injopen=00
battfac=1C
kpafac=C3
kpaoffs=9C
injocfuel=2A
injrampup_battfac=FF
injpwm=FF
injpwmt=FF
als_launch_input=67
rpmk[0]=0B
rpmk[1]=B8
tpsdot_kpadot_conf=00
tpsdotrate[0]=05
tpsdotrate[1]=14
tpsdotrate[2]=28
tpsdotrate[3]=4D
tpsaq[0]=05
tpsaq[1]=07
tpsaq[2]=0C
tpsaq[3]=0E
als_cut_mintps=8C
tpsasync=04
acmult=A0
tpsacold=14
launch_enrich=0D
launch_retard=78
overrun_fuelcut=0C
overrun_fuelresume=0B
rev_limit=46
airden_ignore=62
config11=30
config12=30
config13=0A
batt_cal=C5
fastidle=80
als_max_cut=0D
dbaro=44
tps_low=14
tps_high=96
fan_temp=EA
fan_hyst=02
fan_channel=4F
iac_step_seq=C9
iac_conf=40
iac_max_steps=C8
iac_tps_thres=99
iac_cold_idle_temp=90
iac_warm_idle_temp=A2
iac_cold_rpm=82
iac_warm_rpm=55
iac_cold_start_pos=B3
iac_warm_start_pos=73
iac_afterstart_rpm=0A
iac_afterstart_duration=0A
iac_speed=06
iac_kp=30
iac_ki=0F
iac_kd=23
launch_rpm=2B
iac_integral_limit_dec=5A
iac_integral_limit_inc=F0
iac_integral_deadband=0A
iac_deadband=05
als_cut_maxtps=A6
iac_overclose_interval=B8
iac_ref_pos[0]=85
iac_ref_pos[1]=82
iac_ref_pos[2]=80
iac_ref_pos[3]=7D
iac_ref_pos[4]=7A
iac_ref_pos[5]=7A
iac_ref_pos[6]=78
iac_ref_pos[7]=75
iac_ref_pos[8]=73
iac_ref_pos[9]=70
iac_sol_channel=5F
iac_ign_slope=28
softrpm_range=32
iac_ign_advance_limit=10
iac_ign_retard_limit=24
iac_ign_threshold=08
ego_conf=06
ego_lag=0A
ego_coolant=87
ego_maxtps=FF
ego_maxmap=96
ego_minrpm=05
ego_maxrpm=64
ego_warmup=1E
ego_lean_limit=00
ego_rich_limit=00
ego_pid_kp=40
als_enrich=0D
ego_delta=1A
ego_target=19
ego_pid_window=FF
wbo2_warmup_ramp=A0
als_react_tps=B3
wbo2_abs_limit=E4
wbo2_limit_maxt=A0
wbo2_fallback=60
wbo2_retry_t=06
wbo2_edgetime_corr=0E
wbo2_edgetime_min=15
wbo2_ri_target=96
wbo2_nernstdc_target=8D
wbo2_pump_pw_zero=64
wbo2_calibration=BE
wbo2_heater_pid_kp=46
wbo2_heater_pid_ki=10
wbo2_heater_pid_kd=1A
wbo2_heater_pid_ilimit=80
wbo2_pump_pid_kp=40
wbo2_pump_pid_ki=2E
wbo2_pump_pid_kd=08
wbo2_pump_pid_ilimit=84
wbo2_ri_confidence_scale=80
knock_conf=00
knock_sampling_window=F2
knock1_frequency=29
knock1_gain=00
knock1_integrator=14
knock2_frequency=22
knock2_gain=05
knock2_integrator=00
knock_threshold=FF
knock_noise_scale=D8
knock_max_retard=00
knock_default_retard=00
knock_retard_step=00
knock_retard_delay=FF
knock_advance_step=00
knock_advance_delay=3A
knock_minrpm=46
knock_maxrpm=FF
ve_learn_coolant=D8
ve_learn_max_power=FF
ve_learn_rpm_scale=1E
ve_learn_kpa_scale=1E
ve_learn_ego_scale=43
ve_learn_min_weight=4D
ve_learn_speed=FF
ve_learn_limit=FF
ve_learn_conf=00
lcd_c0=FE
lcd_delay=FF
lcd_backlight=FF
kpa_conf=22
ign_balance=48
als_retard_mintps=80
als_retard_maxtps=99
lcd_default_view=00
primary_trigger=10
secondary_trigger=02
tooth_wheel=0B
trigger_tooth=00
another_trigger_tooth=06
crank_minper=50
tooth_wheel_twidth1=78
tooth_wheel_twidth2=00
cam_sync_r_edge_phase=FF
cam_sync_f_edge_phase=FF
reset_engphase_after=A0
ign_tdcdelay=64
ign_dwell14=2F
ign_dwell6=25
ign_crank_advance=14
ign_out=70
ignchmax=03
engine_off_delay=04
pump_on_mintime=04
fuelpump_channel=60
inj_stage2_rate=FF
inj_stage2_start_tps=00
inj_stage2_start_map=FF
als_deact_rpm=46
als_deact_time=50
als_deact_egt=78
als_retard=46
als_rev_limit=50
misc1out_minrpm=78
misc1out_maxrpm=78
misc1out_mintps=00
misc1out_maxtps=00
misc1out_minmap=00
misc1out_maxmap=00
misc1out_channel=5F
misc2out_minrpm=66
misc2out_maxrpm=66
misc2out_mintps=00
misc2out_maxtps=00
misc2out_minmap=00
misc2out_maxmap=00
misc2out_channel=0F
act_wot_rpm=4F
act_wot_channel=FF
act_rpm_rpm=3C
act_rpm_channel=50
egt1_cal=48
als_tks_channel=68
boost_conf=00
boost_targetoffs=00
boost_minpressure=35
boost_pid_kp=00
boost_pid_ki=00
boost_pid_kd=00
boost_pid_ilimit=00
boost_channel=4F
water_pump_temp=00
hybrid_rpm_a=00
hybrid_rpm_m=00
water_pump_hyst=00
water_pump_channel=3F
toothrel_normal=84
toothrel_missing=16
fuelcut_min_kpa=0A
fuelcut_max_kpa=8C
tach_channel=07
tach_div=11
shiftcut_conf=00
shiftcut_channel=FF
shiftcut_time=01
softrpm_rpm=45
j[0]=2680 2680 2880 2980 2880 2880 2780 2980 2B80 2B80 2B80 3380
j[1]=2B80 2E80 2D80 2F80 3380 3380 3480 3580 3580 3980 3A80 4280
j[2]=3080 3380 3480 3380 3580 3480 3580 3780 3B80 3D80 4280 4A80
j[3]=2F80 3180 3480 3680 3780 3980 3780 3A80 3D80 4180 4480 4D80
j[4]=3380 3380 3880 3A80 3D80 3C80 3B80 3D80 4180 4380 4680 5180
j[5]=3480 3580 3580 3A80 3D80 3B80 3B80 3E80 4280 4980 4D80 5580
j[6]=3B80 3E80 3B80 3C80 3F80 3D80 3F80 4180 4380 4A80 4F80 5680
j[7]=3F80 4080 4280 4280 4580 4380 4780 4A80 4F80 5580 5F80 6580
j[8]=5D80 5E80 5A80 5880 5580 5880 5B80 6580 6C80 7180 7480 7380
j[9]=5F80 6080 5B80 5B80 5C80 5D80 6280 6980 6E80 7180 7480 7280
j[A]=5A80 5B80 5C80 5C80 5E80 6080 6180 6880 6C80 6F80 7180 6F80
j[B]=5580 5780 5780 5A80 5A80 5C80 5F80 6280 6680 6980 6B80 6980
l[0]=47 47 47 47 47 47 47 47 47 47 47 47
l[1]=47 47 47 47 47 47 47 47 47 47 47 47
l[2]=48 48 48 48 48 48 48 48 48 4D 4D 4D
l[3]=4D 4D 4D 4D 4D 4D 4D 4D 4D 4F 4F 4F
l[4]=55 55 55 55 55 55 55 55 55 55 55 5C
l[5]=5C 5C 5C 5C 5C 5C 5C 63 63 63 63 63
l[6]=66 66 66 66 66 66 66 66 66 6B 6B 6B
l[7]=6B 6B 6B 6B 6B 6B 6B 6B 70 70 70 75
l[8]=70 70 70 70 70 70 70 70 70 70 75 75
l[9]=75 75 75 75 75 75 75 75 75 75 75 75
l[A]=75 75 75 7E 7E 7E 7E 7E 7E 7E 7E 7E
l[B]=7E 7E 7E 7E 7E 7E 7E 81 81 81 81 81
n[0]=28 5A 71 81 8B 8F 93 97 99 9C 9E 9D
n[1]=28 5A 6E 7F 8A 8E 92 96 99 9C 9E 9D
n[2]=28 5A 6B 7D 8A 8E 93 97 99 9C 9C 9C
n[3]=27 59 6B 7C 86 8C 90 94 97 98 9A 94
n[4]=28 58 6A 78 81 88 8B 8E 90 92 92 8B
n[5]=28 54 67 72 7B 7E 82 84 84 84 84 7E
n[6]=28 4F 60 68 6E 71 73 73 73 72 72 6F
n[7]=28 45 55 5B 61 62 62 61 62 62 60 5E
n[8]=28 39 45 4A 4C 4E 4E 4F 4E 4D 4D 48
n[9]=28 31 38 3C 3C 3D 3D 3E 3D 3C 3B 37
n[A]=22 29 2A 2B 2B 2B 2C 2C 2C 2D 2C 28
n[B]=1C 1C 1C 1C 1C 1C 1C 1C 1C 1C 1C 1D
k[0]=0B 14 1E 2D 37 41 50 5F 73 82 91 A0
r[0]=07 0C 11 16 1C 21 27 2C 31 37 3C 49
h[0]=02 08 04 01 00 00 40 00
h[1]=00 06 00 06 FF FF FF FF
h[2]=00 10 00 10 00 00 00 00
b[0]=32 4B 64 7D 7D 7D 7D 7D 7D 7D 78 78
t[0]=FF FF FF FF FF FF FF FF
1.0.73
Bye
Date: 2008.09.20. - 16:43:14
End log file
Date: 2008.09.02. - 17:40:16