This car 1.8 20v turbo with four wheel drive, active ( haldex ) with differential gear. The installation was made in such a way that factory ECU controls it the haldex, fuel pump, and the tachometer, VEMS though the ignition, injection, and ALS. This latter does not work well for something. I charge it the dump, and log, somebody realizes the mistake possibly.
ALS config:
als igncut rpm1: 1200
als igncut rpm2: 8000
als retard rpm1: 3100
als retard rpm2: 2800 (lower than als retard RPM1 ??)
deactivation time: 50 s
deactivation egt: 0
reactivation min tps. 70% Did you try to press throttle enough for this to activate ?
fuel enrichment: 5.1%
retard:
- max retard: 30'
- decrase start tps: 35%
- decrase end tps: 40%
- max cut level: 0.0%
- start tps: 40%
- end tps: 60%
http://www.vems.hu/files/MembersPage/poweredracing/datalog200806291522%20als%201.1.27.xls
Terminal log file
Date: 2008.06.29. - 14:55:26
Mon Sep 3 15:10:58 CEST 2007
primep=00
primep_temp_scaling=00
cwl=28
cwh=14
cranking_thres=02
awev=16
awev_temp_scaling=26
awec=02
warmup_clt_range[0]=00
warmup_clt_range[1]=00
warmup_clt_range[2]=00
warmup_clt_range[3]=0B
warmup_clt_range[4]=50
warmup_clt_range[5]=64
warmup_clt_range[6]=78
warmup_clt_range[7]=8C
warmup_clt_range[8]=AA
warmup_clt_range[9]=C8
warmup_clt[0]=BE
warmup_clt[1]=AA
warmup_clt[2]=A0
warmup_clt[3]=96
warmup_clt[4]=8C
warmup_clt[5]=82
warmup_clt[6]=73
warmup_clt[7]=69
warmup_clt[8]=64
warmup_clt[9]=64
warmup_rpm_scale=54
req_fuel=28
divider=01
alternate=13
injopen=00
battfac=1C
kpafac=C4
kpaoffs=9C
injocfuel=2A
injrampup_battfac=FF
injpwm=FF
injpwmt=FF
als_launch_input=67
rpmk[0]=0B
rpmk[1]=B8
tpsdot_kpadot_conf=00
tpsdotrate[0]=0F
tpsdotrate[1]=19
tpsdotrate[2]=32
tpsdotrate[3]=4D
tpsaq[0]=05
tpsaq[1]=00
tpsaq[2]=0F
tpsaq[3]=14
als_cut_mintps=66
tpsasync=04
acmult=A0
tpsacold=14
launch_enrich=00
launch_retard=78
overrun_fuelcut=0D
overrun_fuelresume=0C
rev_limit=4B
airden_ignore=62
config11=30
config12=30
config13=0A
batt_cal=C2
fastidle=80
als_max_cut=00
dbaro=44
tps_low=64
tps_high=C3
fan_temp=F3
fan_hyst=02
fan_channel=4F
iac_step_seq=C9
iac_conf=40
iac_max_steps=C8
iac_tps_thres=4D
iac_cold_idle_temp=90
iac_warm_idle_temp=A2
iac_cold_rpm=82
iac_warm_rpm=55
iac_cold_start_pos=B3
iac_warm_start_pos=73
iac_afterstart_rpm=0A
iac_afterstart_duration=0A
iac_speed=06
iac_kp=30
iac_ki=0F
iac_kd=23
launch_rpm=29
iac_integral_limit_dec=5A
iac_integral_limit_inc=F0
iac_integral_deadband=0A
iac_deadband=05
als_cut_maxtps=99
iac_overclose_interval=B8
iac_ref_pos[0]=85
iac_ref_pos[1]=82
iac_ref_pos[2]=80
iac_ref_pos[3]=7D
iac_ref_pos[4]=7A
iac_ref_pos[5]=7A
iac_ref_pos[6]=78
iac_ref_pos[7]=75
iac_ref_pos[8]=73
iac_ref_pos[9]=70
iac_sol_channel=5F
iac_ign_slope=28
softrpm_range=4B
iac_ign_advance_limit=10
iac_ign_retard_limit=24
iac_ign_threshold=08
ego_conf=06
ego_lag=0A
ego_coolant=87
ego_maxtps=FF
ego_maxmap=96
ego_minrpm=05
ego_maxrpm=64
ego_warmup=1E
ego_lean_limit=00
ego_rich_limit=00
ego_pid_kp=40
als_enrich=0D
ego_delta=1A
ego_target=19
ego_pid_window=FF
wbo2_warmup_ramp=A0
als_react_tps=B3
wbo2_abs_limit=E4
wbo2_limit_maxt=A0
wbo2_fallback=60
wbo2_retry_t=06
als_retard_rpm1=1F
als_retard_rpm2=1C
wbo2_ri_target=96
wbo2_nernstdc_target=8D
wbo2_pump_pw_zero=64
wbo2_calibration=BE
wbo2_heater_pid_kp=46
wbo2_heater_pid_ki=10
wbo2_heater_pid_kd=1A
wbo2_heater_pid_ilimit=80
wbo2_pump_pid_kp=40
wbo2_pump_pid_ki=2E
wbo2_pump_pid_kd=08
wbo2_pump_pid_ilimit=84
wbo2_ri_confidence_scale=80
knock_chan=00 use F0 instead
knock_sampling_window=F2
knock1_frequency=29
knock1_gain=00
knock1_integrator=14
knock2_frequency=22
knock2_gain=05
knock2_integrator=00
knock_threshold=FF
knock_noise_scale=D8
knock_max_retard=00
knock_default_retard=00
knock_retard_step=00
knock_retard_delay=FF
knock_advance_step=00
knock_advance_delay=3A
knock_minrpm=46
knock_maxrpm=FF
ve_learn_coolant=D8
ve_learn_max_power=FF
ve_learn_rpm_scale=1E
ve_learn_kpa_scale=1E
ve_learn_ego_scale=43
ve_learn_min_weight=4D
ve_learn_speed=FF
ve_learn_limit=FF
ve_learn_conf=00
lcd_c0=FE
lcd_delay=FF
lcd_backlight=FF
kpa_conf=22
als_igncut_rpm2=50
als_retard_mintps=59
als_retard_maxtps=66
lcd_default_view=00
primary_trigger=11
secondary_trigger=02
tooth_wheel=23
trigger_tooth=00
another_trigger_tooth=12
crank_minper=50
tooth_wheel_twidth1=28
tooth_wheel_twidth2=00
cam_sync_r_edge_phase=FF
cam_sync_f_edge_phase=FF
reset_engphase_after=A0
ign_tdcdelay=82
ign_dwell14=27
ign_dwell6=25
ign_crank_advance=14
ign_out=70
ignchmax=03
engine_off_delay=04
pump_on_mintime=04
fuelpump_channel=5F
inj_stage2_rate=FF
inj_stage2_start_tps=00
inj_stage2_start_map=FF
als_igncut_rpm1=0C
als_deact_time=32
als_deact_egt=00
als_retard=3C
als_rev_limit=50
misc1out_minrpm=06
misc1out_maxrpm=46
misc1out_mintps=00
misc1out_maxtps=E6
misc1out_minmap=00
misc1out_maxmap=8C
misc1out_channel=5F
misc2out_minrpm=66
misc2out_maxrpm=66
misc2out_mintps=99
misc2out_maxtps=59
misc2out_minmap=73
misc2out_maxmap=A6
misc2out_channel=0F
act_wot_rpm=4F
act_wot_channel=FF
act_rpm_rpm=28
act_rpm_channel=47
egt1_cal=48
als_tks_channel=6F
boost_conf=69
boost_targetoffs=00
boost_minpressure=35
boost_pid_kp=00
boost_pid_ki=00
boost_pid_kd=00
boost_pid_ilimit=00
boost_channel=4F
water_pump_temp=00
hybrid_rpm_a=00
hybrid_rpm_m=00
water_pump_hyst=00
water_pump_channel=3F
toothrel_normal=84
toothrel_missing=D6
fuelcut_min_kpa=0A
fuelcut_max_kpa=7D
tach_channel=0F
tach_div=10
shiftcut_conf=00
shiftcut_channel=FF
shiftcut_time=01
softrpm_rpm=64
j[0]=3E80 4280 4080 4380 4380 4380 4180 4380 4380 4580 4780 4780
j[1]=3F80 4380 4680 4780 4A80 4A80 4980 4C80 4C80 4E80 5080 5180
j[2]=4180 4680 4780 4880 4980 4D80 5080 5380 5480 5780 5880 5D80
j[3]=4380 4880 4980 4E80 5180 5480 5580 5680 5980 5B80 5F80 6580
j[4]=4C80 4E80 5280 5580 5880 5C80 5E80 6180 6380 6480 6880 6D80
j[5]=5380 5780 5A80 5D80 5F80 6280 6480 6880 6980 6C80 6F80 7280
j[6]=5980 5B80 5D80 6580 6A80 6E80 6F80 7280 7580 7780 7980 7C80
j[7]=5F80 6180 6380 6980 6D80 6E80 7080 7280 7480 7680 7680 7780
j[8]=6080 6380 6480 6580 6980 6E80 6F80 7080 6F80 7080 7080 7480
j[9]=5D80 6080 6180 6380 6880 6C80 6D80 6D80 6D80 6C80 6D80 6D80
j[A]=5A80 5D80 5F80 6180 6580 6880 6880 6980 6980 6880 6880 6880
j[B]=5480 5780 5B80 5D80 5F80 6380 6580 6280 6480 6480 6380 6380
l[0]=47 47 47 47 47 47 47 47 47 47 47 47
l[1]=47 47 47 47 47 47 47 47 47 47 47 47
l[2]=48 48 48 48 48 48 48 48 48 4D 4D 4D
l[3]=4D 4D 4D 4D 4D 4D 4D 4D 4D 4F 4F 4F
l[4]=55 55 55 55 55 55 55 55 55 55 55 5C
l[5]=5C 5C 5C 5C 5C 5C 5C 63 63 63 63 63
l[6]=66 66 66 66 66 66 66 66 66 6B 6B 6B
l[7]=6B 6B 6B 6B 6B 6B 6B 6B 70 70 70 75
l[8]=70 70 70 70 70 70 70 70 70 70 75 75
l[9]=75 75 75 75 75 75 75 75 75 75 75 75
l[A]=75 75 75 7E 7E 7E 7E 7E 7E 7E 7E 7E
l[B]=7E 7E 7E 7E 7E 7E 7E 81 81 81 81 81
n[0]=14 16 3C 66 7F 87 8A 8D 8D 8D 8D 8D
n[1]=14 17 3A 63 7C 84 88 8A 8A 8A 8A 88
n[2]=14 16 39 5F 77 7D 80 81 83 83 82 7F
n[3]=14 16 37 57 68 6E 6F 6F 70 71 71 70
n[4]=14 24 35 4F 5B 61 63 64 65 66 67 64
n[5]=14 23 33 46 50 54 57 59 5A 5B 5B 5A
n[6]=14 1E 2C 38 40 47 4A 4B 4D 4D 4D 4D
n[7]=14 1A 25 2E 33 38 3B 3E 3F 40 3F 3C
n[8]=10 16 1C 20 23 26 29 2A 2B 2B 2A 24
n[9]=0C 0F 13 16 18 19 1A 1B 1B 1B 1A 15
n[A]=07 08 0B 0C 0E 0E 0E 0E 0E 0E 0C 09
n[B]=02 00 00 00 00 01 01 02 01 00 00 00
k[0]=0B 14 1E 2D 37 41 50 5F 73 82 91 A0
r[0]=07 0C 11 16 1C 21 27 2C 31 37 3C 45
h[0]=02 08 04 01 00 00 00 00
h[1]=00 12 00 12 FF FF FF FF
h[2]=10 00 10 00 00 00 00 00
y[0]=FF FF FF FF FF FF FF FF FF FF FF FF
y[1]=FF FF FF FF FF FF FF FF FF FF FF FF
y[2]=FF FF FF FF FF FF FF FF FF FF FF FF
y[3]=FF FF FF FF FF FF FF FF FF FF FF FF
y[4]=FF FF FF FF FF FF FF FF FF FF FF FF
y[5]=FF FF FF FF FF FF FF FF FF FF FF FF
y[6]=FF FF FF FF FF FF FF FF FF FF FF FF
y[7]=FF FF FF FF FF FF FF FF FF FF FF FF
y[8]=FF FF FF FF FF FF FF FF FF FF FF FF
y[9]=FF FF FF FF FF FF FF FF FF FF FF FF
y[A]=FF FF FF FF FF FF FF FF FF FF FF FF
y[B]=FF FF FF FF FF FF FF FF FF FF FF FF
1.1.27
Bye
Extracted ALS related variables:
als_launch_input=67
als_cut_mintps=66
als_max_cut=00
launch_rpm=29
softrpm_range=4B
als_enrich=0D
als_react_tps=B3
als_retard_rpm1=1F
als_retard_rpm2=1C
knock_chan=F0 disable knock, you don't want knock_chan=00
als_igncut_rpm2=50
als_retard_mintps=59
als_retard_maxtps=66
als_igncut_rpm1=0C
als_deact_time=32
als_deact_egt=00
als_retard=3C
als_rev_limit=50
als_tks_channel=6F