######  
     #   
   ##    
  #      
 ######  
         

 __          __
 \ \        / /
  \ \  /\  / / 
   \ \/  \/ /  
    \  /\  /   
     \/  \/    
               
               

 _____ 
(  _  )
| ( ) |
| | | |
| (_) |
(_____)
       
       

    ##   
         
   ###   
    ##   
    ##   
    ##   
 ## ##   
  ###    

     #   
         
    ##   
     #   
     #   
     #   
 #   #   
  ###    

IMPORTANT: enter the case-INsensitive alphabetic (no numbers) code AND WRITE SOME SHORT summary of changes (below) if you are saving changes. (not required for previewing changes). Wiki-spamming is not tolerated, will be removed, so it does NOT even show up in history. Spammers go away now.


Visit Preferences to set your user name
Summary of change:
'''link to forum thread''' http://www.vemssupport.com/forum/index.php/topic,1667.0.html == Hardware == '''4AGE 16V''' *bigport head *Wiseco HiComp pistons *ITB - Suzuki Hayabusa 99-07 *stock cams *stock bottom (block, crank, rods) *stock exhaust header https://lh6.googleusercontent.com/-ouJ5IDajbVc/TqxuyJvNBRI/AAAAAAAAGD8/0S85X_NFy6E/s400/IMAG0056.jpg '''EFI''' *VEMS 3.6 (board V3.7) *4x COP, Bosch 0221504474 *4x injector, Bosch 0280150201 (250ccm LowZ) *MAT/IAT - Bosch 0280130073 *CLT - Toyota 89422‑30020 *TPS - Suzuki 13580-24F00 *60+2 trigger wheel with Bosch 0 261 210 090 (VR) sensor *resistor box - Honda EE9 *Wideband - Bosch LSU4 == Software == '''Config''' *Firmware 1.1.96 *Alpha-N/TPS *Primmary Trigger *4x iGBT, Dual Mode Output/Wasted Spark *Sequential injection *EGO correction *no secondary trigger *no IAC/IACV *no MAP '''To be added''' *EGT *IACV *Oil pressure sensor input *Oil temperature sensor input *Launch control switch *Warning Light *Shift Light *vehicle speed input == Summary == Engine run OK for few months. *Had some primary trigger errors in higher RPM (6500+) -(fixed, set Trigger Edge to ''Raising'') *suffered from "VEMS disconnected" while cranking, connecting VEMS, testing coil. -(fixed, rewired loom, better grounds) ===Other data=== '''Cooling system spec''' *thermostat open 82-96C *FAN On 94C *FAN Off 88C
Optional: Add document to category:
Wiki formatting: * is Bullet list ** Bullet list subentry ... '''Bold''', ---- is horizontal ruler, <code> preformatted text... </code> See wiki editing HELP for tables and other formatting tips and tricks.